Thread Rating:
  • 6 Vote(s) - 2.83 Average
  • 1
  • 2
  • 3
  • 4
  • 5
1.6 Hdi engines from other models
#1
Hi Guys

Bit of a newbie when it comes to Berlingo's so you will have to bare with me!

I recently purchased a non runner 2006 1.6 HDI Berlingo van which essentially needs a new lump. I was wondering whether the 1.6 Hdi engine from a Peugeot partner or any other associated models would fit?

My engine code is 9hw? I've seen other engines with different engine codes. Again, does this matter?

Any help would be much appreciated.
Reply
#2
Quite a few people have taken the bull by the horns and fitted a significantly different motor but not many claim to have swapped in a 'near match'
A same-age Partner would be a safe bet but Im not sure about anything else- the mount points will be almost certainly be the same but there are definatly deeper differences some of which you might not be able to work around easily
I looked in the service manual and it lists different citroen models -all with the 1.6 hdi - but with different service /oil change intervals...

I fear you might end up with an 'unfinished project' to sell if you
Reply
#3
I have fitted a 1.6 Diesel Ford Focus engine into a 1.6 Picasso, it was basically the same, apart from the mounts obviously, worst thing was the fuel lines, had to mod a few, in fact I think I fitted the old fuel pump, as the plumbing was hard work.
Reply
#4
(26-03-2013, 09:18 PM)Lighty Wrote:  I have fitted a 1.6 Diesel Ford Focus engine into a 1.6 Picasso, it was basically the same, apart from the mounts obviously, worst thing was the fuel lines, had to mod a few, in fact I think I fitted the old fuel pump, as the plumbing was hard work.

Where there's will & skill,there's a way.
There are no problems,just challenges.(If you believe that you're as daft as me).:thumbsup:
Strawberry flavoured windows  Dodgy
Reply


Forum Jump:


Users browsing this thread: 3 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Tyre Change...old on front new on back
Last Post: Top drive
Today 07:13 AM
» Replies: 6
» Views: 80
Newbie
Last Post: Jed Clampit
Today 12:23 AM
» Replies: 3
» Views: 57
Finally a B9 Haynes Manual
Last Post: Satellitemark
Yesterday 08:26 PM
» Replies: 33
» Views: 2230
Fuel rail pipe replacement
Last Post: Peter Palmer
Yesterday 08:19 PM
» Replies: 2
» Views: 49
REAR AXCEL
Last Post: Tomcat3
Yesterday 07:31 PM
» Replies: 5
» Views: 139
Berlingo B9 2008 Just Testing The Water
Last Post: nickyboy4
Yesterday 06:34 PM
» Replies: 0
» Views: 39
Starting issues
Last Post: technique1966
Yesterday 06:00 PM
» Replies: 0
» Views: 35
Insurance cost
Last Post: jonny705
Yesterday 05:33 PM
» Replies: 0
» Views: 41
Are Mud Flaps the Answer ?
Last Post: Top drive
Yesterday 04:02 PM
» Replies: 11
» Views: 322
Is anyone buying a new car AFTER April 2017?
Last Post: Solent
Yesterday 03:35 PM
» Replies: 1
» Views: 60

[-]
Recent Visitors
Locations of visitors to this page