Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Adjustable fuel pressure regulator on berlingo 1.9d
#1
do installing adjustable fuel pressure regulator does any effects on berlingo 1.9d Dw8 engine?
Reply
#2
I'd like to see you find one! These haven't got a fuel rail
Reply
#3
Welcome to the forum , En Tian.

Are there many Berlingos in Singapore ?

Are you wondering if installing a adjustable fuel regulator makes any difference to the DW8 engine. ?
As Col above said they don't have one . I don't think they need one
Reply
#4
There is a handful, quite easy to find 2nd hand spare, thanks alots for the advise, tot of making it more powerful.
-I have customise my stock air filter,cut away air reasonator. Remove the grill that is behind the logo, drill plenty of holes so air will flow in when I drive.
-Tension my throttle cable, grease my clutch cable, remove my gearknob & sock & grease inside.
-Pulling off the rubber tube that connect at the electronic vacuum regular.
-Replace with coolant in the radiator
-wonder is there still anything I can do to make it more powerful?
Reply
#5
Make it more powerful?
It's a 1.9d?

Swap the engine for a 1.6HDi, or even the 1.4i Gasoline engine... ;-)

How many Km/miles has it gone?
It may need to have the valve clearances done.
Reply
#6
Yup 1.9d Dw8, will not engine swap, would rather sell & purchase mk2 1.6hdi or Mk3, due to the Coe in Singapore. But wonder anyone tried the intake air temp (iat) mod on 1.9d dw8 before?
Reply
#7
Yes that COE is very expensive. Is it the same price for vans? Have you got full use or just the weekend one with red number plates?
Quite honestly, any simple mods you make will yield very little power due to the design of the engine.
Those 1.9's were always a bit slow. You could use the 306/406 XUD 1.9 turbo engine for more power, or turn up up the fuelling on the pump, but you would fall foul of the Singapore emissions regs, and I'm not sure what the penalties are.
The turbo route is probably the best option.
Reply
#8
It's under the cat c commercial vehicle, normal plate can use all day long, just renewed it for another 5 years. In sg, commercial vehicle can only use max 20 year including renewal Coe, after tat force to scrap, other countries like our vehicle very much cos mileage low as sg is a small countries. U mean my current mechanical fuel pump Lucas able to turn up? Almost cos higher idling right?
Reply
#9
I don't mean turn up te idle, I mean fuel delivery. It will give a bit more power, but also black smoke.
Sg are tightening up on emmissions, I have been told they are fining people for leaving engines idling.
Taken to race levels it looks like this https://www.youtube.com/watch?v=7igsQBORSY8 so probably not viable in Sg.
Personally, I would go the XUD turbo route.

What part of Singapore are you from?
[-] The following 1 user says Thank You to Col for this post:
  • malgpz900
Reply
#10
Thanks for sharing the video, yup it will fault the emission, jus tot hw I can adjust my fuel delivery ? Maybe I can adjust back during inspection....I'm living at Bishan North area.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
longitudinal roof rails
Last Post: Corker
Today 02:48 PM
» Replies: 1
» Views: 39
Finally a B9 Haynes Manual
Last Post: Corker
Today 02:38 PM
» Replies: 42
» Views: 2522
Mesh Bulkhead
Last Post: doofer
Today 01:55 PM
» Replies: 1
» Views: 33
Taking along time to heat up/warm the cabin
Last Post: Solent
Today 01:32 PM
» Replies: 1
» Views: 36
Slow starter (diesel)
Last Post: ricc
Today 11:53 AM
» Replies: 15
» Views: 344
2005 Berlingo
Last Post: len glover
Today 10:10 AM
» Replies: 6
» Views: 103
Supermarket Diesel
Last Post: polar
Today 09:28 AM
» Replies: 4
» Views: 61
clunking noise
Last Post: ffrenchie
Today 09:26 AM
» Replies: 5
» Views: 93
BULBS!!
Last Post: Jed Clampit
Yesterday 11:05 PM
» Replies: 17
» Views: 616
TRAILER WANTED
Last Post: Silverberlingo
Yesterday 10:29 PM
» Replies: 4
» Views: 91

[-]
Recent Visitors
Locations of visitors to this page