Thread Rating:
  • 7 Vote(s) - 2.86 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Berlingo Fuel Gauge Showing Nearly Empty
#1
Hi,i have a 2007 berlingo 1.6 hdi 90 van.was driving it & fuel gauge began reading nearly empty & low fuel light was on so i filled up with diesel but gauge still reading nearly empty & light still on.it wont move no matter how much fuel goes in.cant find an access panel to get to sender unit.got under van & did find a wiring plug near tank 1 end had 2 wires & other end had 4 wires in.
id be grateful 4 any advice on fixing problem.Might be a while b4 i,m able to reply to any answers due to work commitments but Thanx in Advance
Reply
#2
Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:

   
2006 2.0hdi 600 with bench seat.  Cool
[-] The following 1 user says Thank You to Rustscrat for this post:
  • bobb
Reply
#3
(15-08-2013, 04:37 PM)Rustscrat Wrote:  Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:
Hi thanx 4 reply & the diagram i,ll have another look under van tomo & c if i can locate those wires now..........Many Thanks....Big Grin
Reply
#4
(13-08-2013, 03:16 PM)bobb Wrote:  Hi,i have a 2007 berlingo 1.6 hdi 90 van.was driving it & fuel gauge began reading nearly empty & low fuel light was on so i filled up with diesel but gauge still reading nearly empty & light still on.it wont move no matter how much fuel goes in.cant find an access panel to get to sender unit.got under van & did find a wiring plug near tank 1 end had 2 wires & other end had 4 wires in.
id be grateful 4 any advice on fixing problem.Might be a while b4 i,m able to reply to any answers due to work commitments but Thanx in Advance
Problem Solved...float on sender unit must of stuck when i ran tank low...put £20 diesel in tank but reading still empty so i just put another £15 of diesel in & gauge went straight to correct reading of all fuel in tank,,,,,,,,,,,,,,,,
[-] The following 1 user says Thank You to bobb for this post:
  • Rustscrat
Reply
#5
(15-08-2013, 04:37 PM)Rustscrat Wrote:  Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:

Hows it going i have the same problem with my 03 1.9 berlingo was just wondering do you have to take the fuel tank of to get at the sender unit or is the an easier access to it
Reply
#6
(08-11-2013, 10:50 AM)Mossym Wrote:  
(15-08-2013, 04:37 PM)Rustscrat Wrote:  Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:

Hows it going i have the same problem with my 03 1.9 berlingo was just wondering do you have to take the fuel tank of to get at the sender unit or is the an easier access to it

Hi thanks for reply,my sender had stuck when i let diesel run low,in the end i filled tank halfway up & took it on a bumpy road & the sender unit freed itself.Might be worth a try before removing sender unit.im not sure if you have to remove tank to get to sender but it does look that way.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Next gen berlingo multispace
Last Post: ron
Today 11:09 PM
» Replies: 18
» Views: 340
Taking along time to heat up/warm the cabin
Last Post: berreke
Today 10:07 PM
» Replies: 17
» Views: 267
clunking noise
Last Post: Johny555
Today 09:58 PM
» Replies: 7
» Views: 139
Supermarket Diesel
Last Post: Opensauce
Today 08:55 PM
» Replies: 8
» Views: 196
Clutch Bleeding
Last Post: Opensauce
Today 08:38 PM
» Replies: 2
» Views: 27
What to look for when buying?
Last Post: my mucker
Today 04:59 PM
» Replies: 7
» Views: 121
Are Mud Flaps the Answer ?
Last Post: doofer
Today 10:01 AM
» Replies: 15
» Views: 502
Head Light Bulbs
Last Post: doofer
Today 09:51 AM
» Replies: 37
» Views: 1225
Help needed have immobiliser fault and fan probl...
Last Post: brajomobil
Today 08:54 AM
» Replies: 3
» Views: 143
New tablet fitted
Last Post: Andre
Today 08:31 AM
» Replies: 1
» Views: 83

[-]
Recent Visitors
Locations of visitors to this page