Thread Rating:
  • 11 Vote(s) - 2.45 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Clutch / Flywheel help!
#1
My father in law's 1.9 berlingo combi (2002) decided to allow the clutch release bearing to implode causing destruction of nearly everything in the housing, Clutch fork, clutch kit, crank shaft sensor (speed sensor I am told) clutch release bearing sleeve are all ordered and to be collected.

The problem I have is that the crank sensor senses two magnetic??? lugs located at 3oclock and 9 oclock on the solid side of the flywheel (non ring gear side)

Some part of the omplosion has snapped these lugs off which means the engine will run rough and warning light will be lit- I have spoken to my local dealer who incorrectly told me i needed part numbers 697606 and 697614- these are however the crank shaft woodruff keys and not the magnets ' sensor drive lugs i need- I have looked on the exploded diagrams on service box and the holes for these lugs can be seen clearly at the edge of the solid part of the flywheel (showing as being at 1oclock and 7oclock) but no menton is made of the lugs which sit in them

You can clearly see the lugs on the picture at this link picture - in fact the ruler rests against them.

Does anyone have any idea where i can get them- the thin im concerned about is that if i buy a new flywheel from peugeot they won't be there as they are not shown on the diagram on servicebox.

Any help greatly appreciated!!!
Reply
#2
Hi, you are correct about the part numbers he has given you.
If you can PM me your Vin No. I should be able to tell you the correct flywheel part No. Confusedcratch:
2006 2.0hdi 600 with bench seat.  Cool
Reply
#3
Ok, your number was throwing me but it actually comes up as a Peugeot Partner number so please check the measurements.

Your flywheel is listed as pt. No. 0532 L1

This is a measurement of 264x132mm with 133 teeth.
I think the 132 could be an inner diameter but I'm not sure.
Let me know if I can help you more.
Confusedalut:
2006 2.0hdi 600 with bench seat.  Cool
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Is anyone buying a new car AFTER April 2017?
Last Post: doofer
Today 03:02 PM
» Replies: 0
» Views: 5
New Berlingo Auto Box - Anyone have one?
Last Post: doofer
Today 02:55 PM
» Replies: 6
» Views: 280
Sop the seatbelt buckle sitting soo low?/aux ste...
Last Post: rickandbev16
Today 02:12 PM
» Replies: 4
» Views: 88
Finally a B9 Haynes Manual
Last Post: rickandbev16
Today 02:04 PM
» Replies: 32
» Views: 2137
Are Mud Flaps the Answer ?
Last Post: doofer
Today 12:41 PM
» Replies: 10
» Views: 270
Head Light Bulbs
Last Post: doofer
Today 09:38 AM
» Replies: 35
» Views: 1063
BerlingoForum.co.uk moving over to BerlingoForum...
Last Post: Bob Southey
Today 07:43 AM
» Replies: 3
» Views: 278
REAR AXCEL
Last Post: ajcommercial
Yesterday 09:36 PM
» Replies: 3
» Views: 102
Odd Issues with Rear Door Sensor
Last Post: dumdum
Yesterday 09:25 PM
» Replies: 1
» Views: 79
display fading (MFD B, not bulb related)
Last Post: sks01773
Yesterday 07:50 PM
» Replies: 42
» Views: 6167

[-]
Recent Visitors
Locations of visitors to this page