Thread Rating:
  • 4 Vote(s) - 3 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Cupid Stunt
#1
So I went to change the glow plugs. Took of the air ducting over the engine etc. Fitted new plugs and reassembled. Engine starts refuses to rev and belches out loads of smoke. Hmm..... disassemble, refit old plugs and try again, seems better. Took it for a run, got about 400 yards and loads of smoke out of exhaust. Bugger. Give up and talk to garage as I've got MOT on Monday. Garage sensibly say, you must have fitted something wrong if it's suddenly got worse.

Start to disassemble then look at choke type thingy in intake duct (what does it do?) I find this is closing after the engine starts. If I hold it open the car runs ok. So then I find that there are two thin pipes coming from somewhere to the bottom of this choke thingy. Reverse the two pipes and all is well.

Hangs head in shame and shuffles away quietly :brickwall::brickwall:
Malc

Stupid computer!
Security system should not fail safe!
Security system should fail dangerous!
[-] The following 1 user says Thank You to crickleymal for this post:
  • ron
Reply
#2
(02-03-2013, 05:14 PM)crickleymal Wrote:  Start to disassemble then look at choke type thingy in intake duct (what does it do?)

Probably a device to divert warm air into the intake, your technical description is probably good enough though. Wink
So where does this bit go then ?
Reply
#3
Two pipes from the egr solenoid... divert exhaust fumes into the intake until engine warm, PITA to be honest... blanked mine off at the exhaust outlet and the intake is as clean as a whistle now... do it Smile
Adam..2003..1.9D..LX..Silver Crew Cab Van.....
If at first you don't succeed, destroy all evidence that you tried.
[-] The following 1 user says Thank You to adam3rdcanvey for this post:
  • ron
Reply
#4
(02-03-2013, 10:01 PM)adam3rdcanvey Wrote:  Two pipes from the egr solenoid... divert exhaust fumes into the intake until engine warm, PITA to be honest... blanked mine off at the exhaust outlet and the intake is as clean as a whistle now... do it Smile

I did wonder about that. There is a big metal pipe comes in from the exhaust at that point. Under the flap valve thingy there is an electrical connection and two air pipes about 3mm internal diameter. It can't be a hot air divert because that bit is in the air intake pipe leading to the choke flap valve thingy.

The air intake ducts do look a bit oily and carbony so maybe I will blank it off.
Malc

Stupid computer!
Security system should not fail safe!
Security system should fail dangerous!
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
clunky gear change
Last Post: dongle99
Today 03:59 PM
» Replies: 0
» Views: 15
Mesh Bulkhead
Last Post: Jelevents
Today 03:13 PM
» Replies: 3
» Views: 55
Supermarket Diesel
Last Post: geoff
Today 03:06 PM
» Replies: 5
» Views: 79
longitudinal roof rails
Last Post: Corker
Today 02:48 PM
» Replies: 1
» Views: 50
Finally a B9 Haynes Manual
Last Post: Corker
Today 02:38 PM
» Replies: 42
» Views: 2532
Taking along time to heat up/warm the cabin
Last Post: Solent
Today 01:32 PM
» Replies: 1
» Views: 49
Slow starter (diesel)
Last Post: ricc
Today 11:53 AM
» Replies: 15
» Views: 350
2005 Berlingo
Last Post: len glover
Today 10:10 AM
» Replies: 6
» Views: 105
clunking noise
Last Post: ffrenchie
Today 09:26 AM
» Replies: 5
» Views: 106
BULBS!!
Last Post: Jed Clampit
Yesterday 11:05 PM
» Replies: 17
» Views: 617

[-]
Recent Visitors
Locations of visitors to this page