Thread Rating:
  • 3 Vote(s) - 3 Average
  • 1
  • 2
  • 3
  • 4
  • 5
EGR Blanked
#1
Hey guys, after 8 months of having my berlingo ive finally got round to blanking off the EGR Valve on my 1.6hdi it hasn't put a light on the dash either so that's another thing ticked off the list.
Reply
#2
Well done.

Did your EGR and inlet piping / manifold need cleaning and also have you noticed any difference in the running of the vehicle yet ?
Reply
#3
To be honest I didn't even look at the inlet or piping, I just blanked it off to prevent any more gunk in the engine. Ive only taken it round the block will keep you posted on how she drives.
Reply
#4
You mean you loosened it off & put one of these ebay blanking plates in, yes? Is that Mk2 or 3 Berlingo?
Reply
#5
Yes that's right spot on lossened two bolt and fitted the blanking plate,took her for a good drive today and runs the very same. It's a 2007 mk2 1.6hdi which is the same engine in the mk3.
Reply
#6
I blanked my egr valve off , 2005 2.0 hdi , it ran ok for @15 miles then ran like the exhaust was blocked and wouldnt rev over 2000 rpm ! It was showing a air flow fault (cannot remember what code ) I took the plate out and it went fine after resetting the codes !
Reply
#7
Blimey that's got me worried now touch wood it will be ok.
Reply
#8
Can the ecu not be reset by a garage, if the blanking plates are available one assumes they can be made to work?
Reply
#9
Thats what i thought ! After reading up about it it should only make your engine run better ! But my car wouldnt have it !
Reply
#10
You can get the EGR deleted with a map saves trying to fit a blanking plate
                                     Smile  It's too orangey for crow's It's just for me and my dog  Smile

                                                        Heart Heart Love a lot trust a few  Dodgy
 
                                                        

                                        
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
BULBS!!
Last Post: Jed Clampit
Yesterday 11:05 PM
» Replies: 17
» Views: 551
Finally a B9 Haynes Manual
Last Post: Satellitemark
Yesterday 10:43 PM
» Replies: 39
» Views: 2471
clunking noise
Last Post: Silverberlingo
Yesterday 10:35 PM
» Replies: 4
» Views: 64
TRAILER WANTED
Last Post: Silverberlingo
Yesterday 10:29 PM
» Replies: 4
» Views: 75
longitudinal roof rails
Last Post: Chrisville
Yesterday 10:27 PM
» Replies: 0
» Views: 18
Head Light Bulbs
Last Post: Hughzie
Yesterday 09:23 PM
» Replies: 36
» Views: 1134
Newbie
Last Post: Jed Clampit
Yesterday 08:37 PM
» Replies: 6
» Views: 87
first time ctroen owner
Last Post: Jed Clampit
Yesterday 08:25 PM
» Replies: 1
» Views: 37
M59 Cooling system change PDF
Last Post: coatess
Yesterday 06:46 PM
» Replies: 1
» Views: 210
What to look for when buying?
Last Post: polar
Yesterday 06:16 PM
» Replies: 6
» Views: 78

[-]
Recent Visitors
Locations of visitors to this page