Thread Rating:
  • 25 Vote(s) - 2.56 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] 2.0 hdi turbo fault
#1
Hi guys

new to posting on the forum but have found it very helpful looking up all the little niggles on my 2003 2.0 hdi berlingo workhorse. I have what sounds like an air leak to, or from the turbo, when you go over 2000rpm it spools up ok and can hear it, but there is no boost. Had a look from under the van this morning, is it possible there could be a crack in the plastic pipe between turbo and inlet ? any advice please

thanks Chris
Reply
#2
It more likely that the boost pipe has just come loose. The boost pile is quite hard and unlikely to just crack. There only held on with a soft silicone joiner and a couple of crappy clamps. ( there 60 mm if you replace with jubilee clamp)
Reply
#3
(06-12-2011, 11:04 PM)duamoHDI Wrote:  It more likely that the boost pipe has just come loose. The boost pile is quite hard and unlikely to just crack. There only held on with a soft silicone joiner and a couple of crappy clamps. ( there 60 mm if you replace with jubilee clamp)

hi pal. my 1.6HDi berlingo makes a similar noise. has its just started to do this? mine has always had the noise from new. also im sure that on the 1.6 HDi the turbo is allways being used. its just works along side the engine from low to high Revs to assist the engine.
1.6 HDi Berlingo van , 2011 plate
Reply
#4
hi
thanks for your response, there is definateley a leak or valve stuck open somewhere. No fault lights on dash or black smoke from the exhaust, it just happened suddenly as i was pulling onto the M25. Drove to work today, and it is way down on power, stopped at my local citroen dealer to check availability of the hoses both of which they say are on back order !!
Reply
#5
as suspected duamo hdi, removed boost pipe and silicone top pipe has a small hole in it, nice one, will patch it up till citroen send me a new one
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Tyre Change...old on front new on back
Last Post: Top drive
Today 07:13 AM
» Replies: 6
» Views: 80
Newbie
Last Post: Jed Clampit
Today 12:23 AM
» Replies: 3
» Views: 57
Finally a B9 Haynes Manual
Last Post: Satellitemark
Yesterday 08:26 PM
» Replies: 33
» Views: 2230
Fuel rail pipe replacement
Last Post: Peter Palmer
Yesterday 08:19 PM
» Replies: 2
» Views: 51
REAR AXCEL
Last Post: Tomcat3
Yesterday 07:31 PM
» Replies: 5
» Views: 139
Berlingo B9 2008 Just Testing The Water
Last Post: nickyboy4
Yesterday 06:34 PM
» Replies: 0
» Views: 39
Starting issues
Last Post: technique1966
Yesterday 06:00 PM
» Replies: 0
» Views: 35
Insurance cost
Last Post: jonny705
Yesterday 05:33 PM
» Replies: 0
» Views: 43
Are Mud Flaps the Answer ?
Last Post: Top drive
Yesterday 04:02 PM
» Replies: 11
» Views: 322
Is anyone buying a new car AFTER April 2017?
Last Post: Solent
Yesterday 03:35 PM
» Replies: 1
» Views: 60

[-]
Recent Visitors
Locations of visitors to this page