Thread Rating:
  • 4 Vote(s) - 4.75 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Rear Calliper
#1
Went out to work last night and had just finished 1st job and a peeping sound but no warning lights, it went off after a few seconds so I thought a door was not closed, checked them and were all ok. Sat for about 10mins then got 2nd job of the evening and then peeping sound again and STOP light comes on intermittent. 5 mins later peeping, STOP light and brake warning light stay on. I dropped off customer and then checked the brake fluid, it was empty!
This afternoon I jacked up the car and noticed its leaking from the off side rear calliper.
Im hoping £150 will fix it.
I DO MISS MY BERLINGO Heart
[-] The following 1 user says Thank You to philip for this post:
  • taxi
Reply
#2
Ouch ! Scary stuff.. Hope it's not as bad as you think.
Former 2011 Mk3 XTR owner Confusedalut:
Reply
#3
(09-03-2013, 07:33 PM)taxi Wrote:  Ouch ! Scary stuff.. Hope it's not as bad as you think.

Thanks!


Sent from my iPhone using Tapatalk
I DO MISS MY BERLINGO Heart
Reply
#4
Make the most of your enforced weekend off.
Former 2011 Mk3 XTR owner Confusedalut:
[-] The following 1 user says Thank You to taxi for this post:
  • philip
Reply
#5
Don't take it to a Main Dealer then! They'll charge you that to change the brake fluid!
Sounds like calipers died. May be the brake was binding and the excess heat damaged the seals.
The Older I get the Better I Was!  Cool
Reply
#6
(09-03-2013, 09:04 PM)OlJeffers Wrote:  Don't take it to a Main Dealer then! They'll charge you that to change the brake fluid!
Sounds like calipers died. May be the brake was binding and the excess heat damaged the seals.

Funny you should say that I could smell a burning a few nights ago.
I'm taking it to my mates garage Citroen Glasgow now charge just to look at a problem £44!


Sent from my iPhone using Tapatalk
I DO MISS MY BERLINGO Heart
Reply
#7
If it's just seals, shouldn't be too hard to sort. Was it leaking from the butt end or around the pads?
Reply
#8
Seized piston Adam? I'm more used to that on bikes!
The Older I get the Better I Was!  Cool
Reply
#9
It's a fairly old-school caliper by the looks of it (I checked out the Budweg exchange units). What I've found often happens to PSA rear calipers is the piston or bore corrodes behind the dust boot, ahead of the square section seal - this jams the piston in nice and tight. Then you put an uncommonly heavy load in the back and it opens the compensating valve; application of hard braking pushes the piston out just enough to work, but it doesn't retract. The "dead leg" of water-filled brake fluid then boils as it's blocked against returning by the load compensator and/or a collapsed flex hose, either pushing the brake pad on harder or blowing out the handbrake lever seals.

On some calipers, winding back the piston without cracking the bleeder, similarly blows out the handbrake seals - Xantias are good for this.
Reply
#10
(09-03-2013, 11:02 PM)addo Wrote:  If it's just seals, shouldn't be too hard to sort. Was it leaking from the butt end or around the pads?
From the back.
I DO MISS MY BERLINGO Heart
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
BULBS!!
Last Post: Jed Clampit
Yesterday 11:05 PM
» Replies: 17
» Views: 549
Finally a B9 Haynes Manual
Last Post: Satellitemark
Yesterday 10:43 PM
» Replies: 39
» Views: 2470
clunking noise
Last Post: Silverberlingo
Yesterday 10:35 PM
» Replies: 4
» Views: 60
TRAILER WANTED
Last Post: Silverberlingo
Yesterday 10:29 PM
» Replies: 4
» Views: 74
longitudinal roof rails
Last Post: Chrisville
Yesterday 10:27 PM
» Replies: 0
» Views: 17
Head Light Bulbs
Last Post: Hughzie
Yesterday 09:23 PM
» Replies: 36
» Views: 1130
Newbie
Last Post: Jed Clampit
Yesterday 08:37 PM
» Replies: 6
» Views: 86
first time ctroen owner
Last Post: Jed Clampit
Yesterday 08:25 PM
» Replies: 1
» Views: 34
M59 Cooling system change PDF
Last Post: coatess
Yesterday 06:46 PM
» Replies: 1
» Views: 209
What to look for when buying?
Last Post: polar
Yesterday 06:16 PM
» Replies: 6
» Views: 74

[-]
Recent Visitors
Locations of visitors to this page