Thread Rating:
  • 3 Vote(s) - 3.67 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Steering & Suspension] Brake regulator spring - where do I buy one?
#1
Peugeot tell me that the brake regulator/compensator spring isnt available as a stand alone item - I have to buy it with the regulator.

A snip at between £80 and £140 depending on which is fitted to my vehicle.

Given how exposed these are they must rust away for everyone, so where do I get a replacement?

thanks
Reply
#2
Hi. Mine snapped..( 02 85000 miles), I bought a spring online on Ebay, mind you, when it arrived, it was an improvised stainless steel "bolt/bonnet latch" crudely but effectively joined together, not the actual spring in the picture online. The new spring should really have had the exact same "pull" strength as the old one..." calibrated"...it had a similar tension...so i fitted it rather than send it back and has worked fine since and has been on a year. They are a bugger to fit, especially if you are on the ground, I carefully cut a 3 sided 6 inch flap of steel floor directly above the valve from inside the boot with a angle grinder, and bent the flap back revealing the complete valve and spring, freed off the seized valve actuator arm and greased the valve, fitted the spring, adjusted it and then bent the flap back down and secured with self tap screws, keeping an eye out for damaging the brake pipes as I went , this method is handy for when you next want to gain access to change the valve or renew brake pipes. You can also weld the flap back as an option and re-cut it next time to gain access.
[-] The following 1 user says Thank You to Barkas for this post:
  • blob
Reply
#3
Cheers!

Fitting isn't an issue - the rear axle is off the car and a recon one is going on this weekend - weather permitting(trailing arm bearing failure).


Does seem ridiculous that a trivial part can't be replaced.

Your experience is the sort of thing that puts me off ebay solutions, I can see that I may end up bending the end loop of the existing spring into a new end.
Reply
#4
There has been a few posts on this issue on the forum have a search. Here is one on fleabay have a read of the description
http://www.ebay.co.uk/itm/Citroen-Berlin...3384d19284
Are we there yet????? No we fecking ain`t  gggggrrrrrrr
Ex 1.6hdi van now 3 seater 1.4 multispace
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Is anyone buying a new car AFTER April 2017?
Last Post: doofer
Today 03:02 PM
» Replies: 0
» Views: 4
New Berlingo Auto Box - Anyone have one?
Last Post: doofer
Today 02:55 PM
» Replies: 6
» Views: 280
Sop the seatbelt buckle sitting soo low?/aux ste...
Last Post: rickandbev16
Today 02:12 PM
» Replies: 4
» Views: 88
Finally a B9 Haynes Manual
Last Post: rickandbev16
Today 02:04 PM
» Replies: 32
» Views: 2137
Are Mud Flaps the Answer ?
Last Post: doofer
Today 12:41 PM
» Replies: 10
» Views: 270
Head Light Bulbs
Last Post: doofer
Today 09:38 AM
» Replies: 35
» Views: 1063
BerlingoForum.co.uk moving over to BerlingoForum...
Last Post: Bob Southey
Today 07:43 AM
» Replies: 3
» Views: 278
REAR AXCEL
Last Post: ajcommercial
Yesterday 09:36 PM
» Replies: 3
» Views: 101
Odd Issues with Rear Door Sensor
Last Post: dumdum
Yesterday 09:25 PM
» Replies: 1
» Views: 79
display fading (MFD B, not bulb related)
Last Post: sks01773
Yesterday 07:50 PM
» Replies: 42
» Views: 6167

[-]
Recent Visitors
Locations of visitors to this page