Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Transmission] Berlingo drive shaft oil seal replacement advice please.
#1
Hi
Just wondering if anyone has a how to guide on replacing the oil seal in my gearbox where the drive shaft goes fits into.(passenger side) please. 2004 Berlingo 1.9d
I am assuming it is the oil seal.
I replaced the strut yesterday and while replacing it the hub pulled the drive shaft out a little bit and oil started to leak from the gearbox. i pushed the drive shaft back in which stopped the oil(or so i though) coming out quickly but when i got up this morning there is a drip coming from the gearbox where the shaft goes in.
Reply
#2
How much oil? It may only be residual oil dropping off.
Strawberry flavoured windows  Dodgy
Reply
#3
Thanks for the reply Ron.
I thought it was maybe residual oil but i cleaned the oil up from last night and there was a little pool this morning and its kept dripping throughout today. Sad
Reply
#4
The seal is easy to replace just be careful to drift it in square & feed the shaft in slow & level.While you're at it,changing the trans oil is always a good idea.Synthetic,of course. Wink Big Grin
Strawberry flavoured windows  Dodgy
[-] The following 1 user says Thank You to ron for this post:
  • tmm
Reply
#5
On the nearside the job is as it looks but when I did the seal on mine I found the CV joint was badly choroded where it meets the seal so I had to wire wool the face to a smooth clean finish. No problems since ( fingers crossed ) it has been approx 15k miles ... The Drivers side I haven't attempted yet..
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Tyre Change...old on front new on back
Last Post: malgpz900
Today 09:20 PM
» Replies: 2
» Views: 38
Finally a B9 Haynes Manual
Last Post: Satellitemark
Today 08:26 PM
» Replies: 33
» Views: 2202
Fuel rail pipe replacement
Last Post: Peter Palmer
Today 08:19 PM
» Replies: 2
» Views: 33
REAR AXCEL
Last Post: Tomcat3
Today 07:31 PM
» Replies: 5
» Views: 129
Berlingo B9 2008 Just Testing The Water
Last Post: nickyboy4
Today 06:34 PM
» Replies: 0
» Views: 26
Starting issues
Last Post: technique1966
Today 06:00 PM
» Replies: 0
» Views: 26
Insurance cost
Last Post: jonny705
Today 05:33 PM
» Replies: 0
» Views: 30
Newbie
Last Post: j.ted
Today 04:40 PM
» Replies: 2
» Views: 41
Are Mud Flaps the Answer ?
Last Post: Top drive
Today 04:02 PM
» Replies: 11
» Views: 310
Is anyone buying a new car AFTER April 2017?
Last Post: Solent
Today 03:35 PM
» Replies: 1
» Views: 51

[-]
Recent Visitors
Locations of visitors to this page