Thread Rating:
  • 5 Vote(s) - 2.2 Average
  • 1
  • 2
  • 3
  • 4
  • 5
noisy engine ,continuous fan
#1
hi have 2002 1.9 Dw 8 engine berlingo, changed starter motor, after starter motor changedm engine rattling like bag of nails,also cooling fan heater on permanently, have checked injectors, all ok, any suggestions please, desperate.
Reply
#2
When you changed the starter motor, if you disconnected the battery, did you
do a BSI reset?
Welcome to the forums.
The Older I get the Better I Was!  Cool
Reply
#3
(18-08-2012, 04:10 PM)fatherbear Wrote:  hi have 2002 1.9 Dw 8 engine berlingo, changed starter motor, after starter motor changedm engine rattling like bag of nails,also cooling fan heater on permanently, have checked injectors, all ok, any suggestions please, desperate.

Hi,If the noise only appeared after changing the starter motor,suspect the starter.The pinion may be staying in mesh,hence the noise.Good luck. Re the fan,disconnect the switch on the rad.If the fan stops,bridge the plug terminals & the fan should run indicating a faulty sw.If the fan doesn't run the fault is in the harness.
KEEP HANDS CLEAR OF MOVING PARTS.Some of the fan checks can be done ign on,eng stopped.
Strawberry flavoured windows  Dodgy
Reply
#4
(18-08-2012, 06:15 PM)OlJeffers Wrote:  When you changed the starter motor, if you disconnected the battery, did you
do a BSI reset?
Welcome to the forums.

Hi, what is a BSI reset
Reply
#5
http://www.bba-reman.com/content.aspx?co...ol_failure

Scroll down to final paragraph and follow instructions closely.HTHConfusedtudy:
The Older I get the Better I Was!  Cool
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Newbie
Last Post: Onall4
Today 03:16 PM
» Replies: 0
» Views: 3
Next gen berlingo multispace
Last Post: Trevor
Today 02:50 PM
» Replies: 5
» Views: 86
Finally a B9 Haynes Manual
Last Post: Satellitemark
Today 02:32 PM
» Replies: 37
» Views: 2378
glow plugs
Last Post: z1000pete
Today 10:21 AM
» Replies: 0
» Views: 25
Is anyone buying a new car AFTER April 2017?
Last Post: doofer
Today 09:10 AM
» Replies: 12
» Views: 224
Sop the seatbelt buckle sitting soo low?/aux ste...
Last Post: Hora
Today 07:04 AM
» Replies: 5
» Views: 154
Fuel rail pipe replacement
Last Post: polar
Today 06:54 AM
» Replies: 4
» Views: 101
600lx or 800lx
Last Post: dumdum
Yesterday 11:12 PM
» Replies: 1
» Views: 46
Advise please on known problem tyre scrubbing
Last Post: shncoe1
Yesterday 10:12 PM
» Replies: 19
» Views: 1569
Another seat belt question
Last Post: berreke
Yesterday 09:02 PM
» Replies: 1
» Views: 51

[-]
Recent Visitors
Locations of visitors to this page