Thread Rating:
  • 19 Vote(s) - 2.95 Average
  • 1
  • 2
  • 3
  • 4
  • 5
replace 99 blingo van 1.9d fuel filter
#1
hi, is it hard to replace a diesel fuel filter on a 99 blingo van dw8.?. i have bought filter just need to know if theres any tips/problems with the job.?. thankyou.
Reply
#2
Did my 98 Blingo last year. Only problem was the amount of bleeding at the filter and Lucas injector pump nipples I had to do after fitting the filter. Even although the air bubbles had stopped I had to keep bleeding until the sodding thing started. Thank goodness for the rubber priming bulb thing. Good luck!
Tony L
Reply
#3
Hi Tony L If your fuel filter housing is like my 2002 model and I think it is, it's easy to change.
Make sure you put a rag under the filter housing to catch any spillage. Put a bit of rubber tube on the drain cock on the bottom of the housing and drain out fuel. Undo the cover clip and remove old filter. Clean inside the housing with a bit of kitchen roll. Install new filter and pump fuel in with cover still removed until up to level. Replace cover and with great care replace fastening clip, be gentle, I broke mine and had to fix it on with a large hoseclip.
Mine has a plastic button on the side of the filter housing as the primer pump, with the cover on pump away and get an assistant to start the vehicle, you will hear electric fuel pump clicking away, with the engine cranking keep pumping and it should fire up and keep running..... good luck.

Pappy
Reply
#4
Hi,


on my M49 DW8 i did the following

1) unclip filter housing lid
2) remove old filter
3) place new o rings onto new filter -
4) Fit new filter into housing
5) clip back in place
6) press priming pump lots of times
7) start van and hold a *light* throttle - if it cuts out then repeat step 6 until successful

may not be entirely factory procedure but it works for me Smile
Reply
#5
..i chickened out and got the local mechanic to put a diesel filter on for me ...thanks....
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Fuel Guage wrong
Last Post: Solent
Today 07:36 AM
» Replies: 4
» Views: 105
REAR AXCEL
Last Post: polar
Today 06:12 AM
» Replies: 1
» Views: 22
Odd Issues with Rear Door Sensor
Last Post: GerardKeating
Today 12:27 AM
» Replies: 0
» Views: 16
Gearbox Fluid
Last Post: AlanS
Today 12:18 AM
» Replies: 14
» Views: 347
Longitudinal Roof rails on 2010 model
Last Post: Chrisville
Yesterday 08:42 PM
» Replies: 0
» Views: 36
radio code
Last Post: Tomcat3
Yesterday 07:14 PM
» Replies: 1
» Views: 45
Donation
Last Post: terryd999
Yesterday 06:15 PM
» Replies: 2
» Views: 48
Beeping with no error lights!!!
Last Post: sjparky
Yesterday 05:34 PM
» Replies: 11
» Views: 3770
Good Evening to you all.
Last Post: ron
Yesterday 04:33 PM
» Replies: 7
» Views: 214
New Berlingo Auto Box - Anyone have one?
Last Post: rubberrat
Yesterday 01:30 PM
» Replies: 3
» Views: 217

[-]
Recent Visitors
Locations of visitors to this page