Thread Rating:
  • 25 Vote(s) - 3.24 Average
  • 1
  • 2
  • 3
  • 4
  • 5
were is the glow plug relay
#1
Rainbow 
Hi, have looked everywhere for the heater plugs relay, there is no heat light showing on the dashboard when i put the ignition on, I am prosuming that the relay is at fault, cannot find it under the bonnet, have looked behind the battery tray etc.
it a 04 DW12 HDI, would be gratefull for any help. thanks.Confusedunny:
Reply
#2
Have a trawl around the site, this has been discussed before....
Berlingo Multispace 2.0HDI '54 reg Mediterranean Blue
Reply
#3
Yep - don't assume that just because the light doesn't come on that it isn't working - it just doesn't need too. Does it start ok?

The light on mine only comes on in winter.
2010 (B9) Berlingo Multispace XTR HDi 112 - Kyanos Blue
Previously - 2002 (M49) Berlingo Multispace 2.0 HDi Diesel - Arctic Steel
Reply
#4
I've never seen a glowplug light come on yet. With a modern HDI diesel you just turn the key. If its starting ok theres no problem.
Reply
#5
Correct both.
The light only comes on during cold conditions.
Does mention this in the handbook.
Had mine since April and not come on yet.
Starts first time with no problems.:thumbsup:
Reply
#6
Did anyone find the location of this relay? I'm just about to change mine (fault reported in Lexia) so would like to know where to look.
How much is the fish?
Reply
#7
(21-10-2011, 10:58 AM)knobblywobbly Wrote:  Did anyone find the location of this relay? I'm just about to change mine (fault reported in Lexia) so would like to know where to look.

Is it to the left of the nearside headlight?
If not, under battery tray?
Or trace wiring from glowplugs themselves to find the relay...

Think it varies quite a lot from model to model anyway...

Happy hunting!
Adam..2003..1.9D..LX..Silver Crew Cab Van.....
If at first you don't succeed, destroy all evidence that you tried.
Reply
#8
HI, Thanks for all the info, I still havent found the relay. It does start on the third turn of the key, the battery is quite oldish from the way it looks, battery has 12.5 volts in it,Engine turns over quickly then slows down ,seems to lack amps ??. Is it just a matter of a new battery ?? £65.00 to find out.
Once its running its goes well, 51K miles etc.
Reply
#9
(21-10-2011, 03:59 PM)bechstein Wrote:  HI, Thanks for all the info, I still havent found the relay. It does start on the third turn of the key, the battery is quite oldish from the way it looks, battery has 12.5 volts in it,Engine turns over quickly then slows down ,seems to lack amps ??. Is it just a matter of a new battery ?? £65.00 to find out.
Once its running its goes well, 51K miles etc.

Before you change the battery check all of the heavy (high current cables) are tight at their terminals as this can soon drag battery performance down.
If the battery is showing 12.5 volts with the engine off it may be OK but have the battery tested for high current drain ability.
HTH :thumbsup:

The Older I get the Better I Was!  Cool
Reply
#10
(21-10-2011, 03:59 PM)bechstein Wrote:  HI, Thanks for all the info, I still havent found the relay.

I have!!!

It´s near the nearside headlight - you have to remove the air intake that goes from the front grill to get at it. Once this is off look down and you´ll see it bolted to a rib at the front.
How much is the fish?
[-] The following 1 user says Thank You to knobblywobbly for this post:
  • adam3rdcanvey
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
BULBS!!
Last Post: Hughzie
Today 09:43 PM
» Replies: 14
» Views: 521
Head Light Bulbs
Last Post: Hughzie
Today 09:23 PM
» Replies: 36
» Views: 1118
Finally a B9 Haynes Manual
Last Post: Hughzie
Today 08:53 PM
» Replies: 38
» Views: 2452
Newbie
Last Post: Jed Clampit
Today 08:37 PM
» Replies: 6
» Views: 84
first time ctroen owner
Last Post: Jed Clampit
Today 08:25 PM
» Replies: 1
» Views: 27
TRAILER WANTED
Last Post: Tomcat3
Today 07:15 PM
» Replies: 3
» Views: 63
M59 Cooling system change PDF
Last Post: coatess
Today 06:46 PM
» Replies: 1
» Views: 206
What to look for when buying?
Last Post: polar
Today 06:16 PM
» Replies: 6
» Views: 73
clunking noise
Last Post: polar
Today 06:13 PM
» Replies: 3
» Views: 50
Next gen berlingo multispace
Last Post: doofer
Today 05:55 PM
» Replies: 9
» Views: 172

[-]
Recent Visitors
Locations of visitors to this page