Thread Rating:
  • 5 Vote(s) - 2 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Identify engine and gearbox
#1
Hi all. How do I identify which engine and gearbox I have?

Jan 2003 ( 52 reg ) 1.9 Diesel Van.

I am about to commence an epic 'rebuild'. Replacement gearbox, clutch, thrust bearing and pressure plate, cambelt, water pump, alternator/ps pump belt and an oil and filter change.

Might need a tailpiece to the exhaust and brake pads too. Depending on the engine Id I may need a crankshaft pulley I suspect as something down there is making one hell of a racket!

Anything else i should consider while I'm at it?

:eek:
Reply
#2
Replace the cambelt idler pulleys as well.As far as identification goes,if the eng/trans is all original,reg or V.I.N. should be enough for obtaining spares.As a tip,try GSF for parts,I've found them good.:thumbsup:
Strawberry flavoured windows  Dodgy
[-] The following 2 users say Thank You to ron for this post:
  • addo, nimbusgb
Reply
#3
Thanks for that but I'm looking for a recon or used gearbox so I need to know what I'm looking for so a part number would be great.

Ordered a workshop manual on disk so hopefully that will be helpful.

Added idler pulleys to the list!
Reply
#4
    Look for the gearbox ID code, it's etched usually on the front or top of the box, there is a short code (which you want) followed by a unit serial. In the example shown the ID is 20CD74.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
23 plate Citreon Berlingo classed as a van
Last Post: evdama
Today 09:17 AM
» Replies: 3
» Views: 49
Service interval notice
Last Post: evdama
Today 09:06 AM
» Replies: 8
» Views: 379
Winter Tyres
Last Post: evdama
Today 09:03 AM
» Replies: 1
» Views: 44
The creation of my personal solo-travellor.
Last Post: EM58
Yesterday 06:17 PM
» Replies: 12
» Views: 748
M59 Throttle pedal
Last Post: evdama
Yesterday 01:10 PM
» Replies: 5
» Views: 187
Berlingo 2007 1.6 hdi - intermittent sticky acce...
Last Post: Romahomepete
Yesterday 01:05 PM
» Replies: 7
» Views: 333
roof rack with slats
Last Post: BigVtwin996
Yesterday 11:53 AM
» Replies: 4
» Views: 196
Battery upgrade
Last Post: evdama
27-03-2024 03:58 PM
» Replies: 0
» Views: 106
Wanted: 2003 M59 steering rack
Last Post: evdama
27-03-2024 12:45 PM
» Replies: 1
» Views: 60
Airbag Fault Code
Last Post: Cumbrian
26-03-2024 03:06 PM
» Replies: 1
» Views: 219

[-]
Recent Visitors
Locations of visitors to this page

[-]
Hosting by

QuickHostUK