|
Search Results
|
| Post |
Author |
Forum |
Replies |
Views |
Posted
[asc]
|
| |
|
Thread: 2002 1.9d
Post: RE: 2002 1.9d
| Our multispace is coming up to 210,000 now. Is great around local area, i find Is the long motorway hills that show the lack of power with DW8.
Apart from the cost of road tax is probably the cheapes... |
|
Kieron G |
M49 Berlingo
|
6 |
148 |
25-02-2023, 11:29 PM |
| |
|
Thread: Stiff gear shift after lack of use.
Post: RE: Stiff gear shift after lack of use.
| Maybe check / change the gearbox oil and go for a good run .
Changing the gearbox oil in our Berlingo made a noticeable difference |
|
Kieron G |
M59 Berlingo
|
4 |
280 |
02-02-2023, 08:52 AM |
| |
|
Thread: Ignition barrel
Post: RE: Ignition barrel
| Could you cut and solder the wires of the new barrel connector to the female end of old barrel connector plug? With heat shrink could be a tidy job |
|
Kieron G |
M49 Berlingo
|
1 |
125 |
01-02-2023, 06:05 PM |
| |
|
Thread: 2003 Berlingo M59 DW8B no start (SOLVED)
Post: RE: 2003 Berlingo M59 DW8B no start
| Re the water in diesel, when i had this before the diesel looked like milk when i tried to bleed the engine. That was a marine engine on red diesel though |
|
Kieron G |
M59 Berlingo
|
40 |
1,178 |
16-01-2023, 07:21 PM |
| |
|
Thread: 2003 Berlingo M59 DW8B no start (SOLVED)
Post: RE: 2003 Berlingo M59 DW8B no start
| On our 2001 Dw8 ( M49 ) there is a light yellow key symbol icon on the dash which lights if the ignition key is not recognised by the immobiliser when ignition is turned on. the engine turns over but ... |
|
Kieron G |
M59 Berlingo
|
40 |
1,178 |
16-01-2023, 07:17 PM |
| |
|
Thread: Weird limp mode with lots of smoke
Post: RE: Weird limp mode with lots of smoke
| Ok just a suggestion, if not that I don't know what would be causing an intermittent fault like you describe |
|
Kieron G |
M59 Berlingo
|
4 |
285 |
06-01-2023, 06:10 PM |
| |
|
Thread: Weird limp mode with lots of smoke
Post: RE: Weird limp mode with lots of smoke
| I think it might possibly be something to do with the EGR. I had a similar problem. Maybe the stainless steel pipe from the exhaust manifold to the inlet is choked with thick black crud. You could te... |
|
Kieron G |
M59 Berlingo
|
4 |
285 |
04-01-2023, 10:48 PM |
| |
|
Thread: Rear brake shoes replaced
Post: RE: Rear brake shoes replaced
| From changing shoes on my M49 the automatic adjusters should take up the free play on shoes when handbrake is repeatedly applied. He shouldn't need to come back and re adjust them. From previous exper... |
|
Kieron G |
M59 Berlingo
|
6 |
283 |
19-12-2022, 10:03 PM |
| |
|
Thread: Hazard light switch malfunction
Post: RE: Hazard light switch malfunction
| Just wd40 or similar I would try |
|
Kieron G |
M49 Berlingo
|
9 |
262 |
13-12-2022, 11:30 PM |
| |
|
Thread: Hazard light switch malfunction
Post: RE: Hazard light switch malfunction
| Quick spray in gap between housing and button on switch with maintenance spray might free it off if it's sticking |
|
Kieron G |
M49 Berlingo
|
9 |
262 |
13-12-2022, 07:28 PM |
| |
|
Thread: Failing to start, plethora of fault codes
Post: RE: Failing to start, plethora of fault codes
| Well out of my depth with later Berlingo electrics. But could the fault be a bad main earth. Had this on a truck before where I tested it by running a jump lead from negative terminal on battery to an... |
|
Kieron G |
B9 Second Generation
|
9 |
556 |
29-11-2022, 04:44 PM |
| |
|
Thread: 1.9d Lucas berlingo died while driving
Post: RE: 1.9d Lucas berlingo died while driving
| Yeah I get that about water Only suggested that might have hydrauliced as you mentioned that water was coming out of inlet. I have seen bent rod on diesel before so I think it can happen. Was just a ... |
|
Kieron G |
M59 Berlingo
|
28 |
1,082 |
06-11-2022, 10:59 AM |
| |
|
Thread: 1.9d Lucas berlingo died while driving
Post: RE: 1.9d Lucas berlingo died while driving
| Getting hold of a good replacement 1.9 Dw8 should be easy enough. Personally I would buy an mot failure with a good engine as opposed to buying an engine on a pallet. Then you know is a good one and ... |
|
Kieron G |
M59 Berlingo
|
28 |
1,082 |
05-11-2022, 07:47 PM |
| |
|
Thread: 2005 Berlingo Multispace
Post: RE: 2005 Berlingo Multispace
| I went through a raft of problems all at once with my sister's old 1.9 after years of brilliant service. Come out the other side and got a great little van / car again. Fitting a new battery seemed to... |
|
Kieron G |
Introductions
|
6 |
329 |
05-11-2022, 07:39 PM |
| |
|
Thread: 1.9d Lucas berlingo died while driving
Post: RE: 1.9d Lucas berlingo died while driving
| Possible that con rod bent on number 3 cylinder if engine hydrauliced with water. Also I guess you already know but don't count No 1 cylinder from the front pulley end of engine like I did |
|
Kieron G |
M59 Berlingo
|
28 |
1,082 |
01-11-2022, 09:25 AM |
| |
|
Thread: Coolant system overhaul
Post: RE: Coolant system overhaul
| I've been having a pain with radiator bottom hose on 1.8 petrol after fitting new radiator. Metal end of bottom hose pushes in with O ring and held with spring type clip. Keeps popping out when system... |
|
Kieron G |
M49 Berlingo
|
64 |
2,202 |
21-10-2022, 10:20 PM |
| |
|
Thread: rear seat
Post: RE: rear seat
| If you don't have an account and can use someone's Facebook to search marketplace. Finding it really good for spares at the moment. Even breakers around here list cars on there. Finding with M49 / 59 ... |
|
Kieron G |
Wanted To Buy/Trade
|
2 |
213 |
26-09-2022, 10:53 AM |
| |
|
Thread: Floor template
Post: RE: Floor template
| Could you remove the carpet out and make a template out of cardboard ? |
|
Kieron G |
B9 Second Generation
|
2 |
252 |
26-09-2022, 10:46 AM |
| |
|
Thread: Speedometer stopping Nightrider turbo boost
Post: RE: Speedometer stopping Nightrider turbo boost
| Do you drive past a power station maybe. Had this with a truck where gauges go haywire when passing the transformers at Drax power |
|
Kieron G |
M59 Berlingo
|
22 |
955 |
14-09-2022, 10:29 PM |
| |
|
Thread: 3 persons in a 1997 2 Drs Delivery Van (Holland)
Post: RE: 3 persons in a 1997 2 Drs Delivery Van (Hollan...
| The wheelchair M49 I saw in a breakers had 1 extra seat in back if I remember right so is possible to get a rear single seat. Just the hassle with vehicle conformity / insurance |
|
Kieron G |
M49 Berlingo
|
5 |
381 |
14-09-2022, 10:24 PM |
