Search Results
Post Author Forum Replies Views Posted [asc]
    Thread: Bleeding problems
Post: RE: Bleeding problems

Did you pressure bleed the brakes?
V6BOY M59 Berlingo 5 1,822 10-03-2020, 10:45 PM
    Thread: SOLVED: RHS (O/S) engine mount 1.6HDi (2007)
Post: RE: SOLVED: RHS (O/S) engine mount 1.6HDi (2007)

I remember looking at this engine mount when I was changing my timing belt a few years back and wondering how you remove it. So and decent strap turned anticlockwise does the job I'll remember this fo...
V6BOY M59 Berlingo 25 6,609 08-03-2020, 12:32 PM
    Thread: Berlingo 1.4 (2002) not starting
Post: RE: Berlingo 1.4 (2002) not starting

I still wouldn't rule out a bad battery even if newish, battery needs to be load tested to confirm. Can you try a known good battery from another vehicle? Then I would check all wiring on the starter ...
V6BOY M59 Berlingo 10 2,453 02-02-2020, 03:23 PM
    Thread: Injector headache
Post: RE: Injector headache

It's paramount that you cut the injector seats on a diesel specially if they are leaking in the first place.
V6BOY M59 Berlingo 12 3,792 02-02-2020, 02:57 PM
    Thread: Bloody bleeding brakes!
Post: RE: Bloody bleeding brakes!

As above jj9 recommendation is a good one and will do the job if you can stretch a little more https://www.ebay.co.uk/itm/Sealey-VS820-...ect=mobile I have both types and both work well.
V6BOY M59 Berlingo 15 4,364 20-01-2020, 11:30 PM
    Thread: Bloody bleeding brakes!
Post: RE: Bloody bleeding brakes!

Ahh i see because if you connect up a pressure type one and pressurize the system you would hear and see any leaks fairly noticeably.
V6BOY M59 Berlingo 15 4,364 20-01-2020, 07:07 PM
    Thread: Bloody bleeding brakes!
Post: RE: Bloody bleeding brakes!

Are you using a pressure bleeder?
V6BOY M59 Berlingo 15 4,364 20-01-2020, 05:44 PM
    Thread: non start
Post: RE: non start

Have you done a BSI reset yet?
V6BOY M59 Berlingo 3 1,405 19-10-2019, 06:45 PM
    Thread: CAT/DPF removal - can it be pulled out upwards?
Post: RE: CAT/DPF removal - can it be pulled out upwards...

Yep dropped the cat on the MK2 fairy easy unsure about the mini. But good tip is cover the rad with cardboard save the fins getting damaged it will be tight.
V6BOY M59 Berlingo 5 1,901 18-10-2019, 07:37 PM
    Thread: sell up or repair ?
Post: RE: sell up or repair ?

You have to ask yourself the question how far do you want to go with a 16 year old van. If you were to do the work yourself I'd say go for it fix it. But if you will be paying someone it would have to...
V6BOY M59 Berlingo 8 6,532 17-10-2019, 10:02 AM
    Thread: Electrical circuit fault
Post: RE: Electrical circuit fault

You should be getting 14 volt from the battery with the engine running, to test a bad battery it needs to be load tested.
V6BOY B9 Second Generation 6 7,962 07-10-2019, 12:49 PM
    Thread: Corrosion
Post: RE: Corrosion

Old Berlingos are pretty good at avoiding corrosion, but Id still have a dam good look underneath an early one.
V6BOY M59 Berlingo 8 7,625 16-09-2019, 08:49 PM
    Thread: Best quality anti roll bar drop links ?
Post: RE: Best quality anti roll bar drop links ?

Been in your situation before cheap ones are false economy, MEYLE and Lemforder are the ones I'd go for these days.
V6BOY M59 Berlingo 2 2,134 01-09-2019, 09:07 PM
    Thread: Water in passenger footwell
Post: RE: Water in passenger footwell

Have you checked the passenger door seal also?
V6BOY M59 Berlingo 17 12,165 15-08-2019, 10:34 PM
    Thread: Water in passenger footwell
Post: RE: Water in passenger footwell

Very common problem remove wipers and scuttle panel give it a dam good clean out drain points each side will be blocked
V6BOY M59 Berlingo 17 12,165 10-08-2019, 06:28 PM
    Thread: fuel pump not priming after clutch change 2003 1.6i
Post: RE: fuel pump not priming after clutch change 2003...

My first port of call now would be find the inertia switch and press that. Not sure exactly where it is on your model have a good look round the engine bay it will be a large black or red button.
V6BOY M59 Berlingo 3 1,901 10-07-2019, 09:10 AM
    Thread: airbag stolen - is it a thing
Post: RE: airbag stolen - is it a thing

Wow never seen that before a break in just to seal an airbag, shame that's the society we live in now I suppose.
V6BOY B9 Second Generation 3 3,070 22-03-2019, 09:13 AM
    Thread: puff of blue-ish smoke on startup
Post: RE: puff of blue-ish smoke on startup

My 2007 1.6HDI has done the exact same since I bought it from 30k I guess it's slightly leaking valve stem sills.
V6BOY M59 Berlingo 12 11,874 20-03-2019, 08:45 AM
    Thread: Tyres and suspension
Post: RE: Tyres and suspension

All the fancy laser alignment systems are only as good as the person operating it, believe it or not that might just be your problem.
V6BOY B9 Second Generation 29 17,861 20-01-2019, 03:50 PM
    Thread: GSF discount
Post: RE: GSF discount

Wow that's less then a pint of beer where I live.
V6BOY General Chat 4 2,503 08-01-2019, 04:44 PM