Berlingo Forum › Search
Results

Search Results
Post Author Forum Replies Views Posted [asc]
    Thread: Question on Injectors 1.6 Hdi
Post: RE: Question on Injectors 1.6 Hdi
No, coding is nonsense. The adaptation process takes place while driving under load. ~200 a pop.
 SinsBird M59 Berlingo 4 635 29-10-2023, 08:06 AM
    Thread: 2008 1.6HDi rear wiper motor kaput (van door type)
Post: RE: 2008 1.6HDi rear wiper motor kaput (van door t...
2dr model part number 6405F5, other 6405N4.
 SinsBird M59 Berlingo 9 806 22-07-2023, 07:45 PM
    Thread: Hose problem
Post: RE: Hose problem
Yes, it's not critical, looks like a mess though.
 SinsBird M59 Berlingo 4 409 21-07-2023, 08:11 PM
    Thread: Door seals
Post: RE: Door seals
Perhaps 9023nl?
 SinsBird M59 Berlingo 2 487 20-06-2023, 12:50 AM
    Thread: 3rd gear crunch
Post: RE: 3rd gear crunch
(04-01-2023, 12:12 AM)Jameshannaa Wrote:  ...If the problem is in the synchros you can do rev matching and double clutching when shifting. When shifting from second to third, clutch neutral, clu...
 SinsBird Member Submitted Tutorials & How To's 4 1,439 04-01-2023, 12:47 PM
    Thread: 3rd gear crunch
Post: RE: 3rd gear crunch
Usually caused by worn synchro rings in the gearbox, but sometimes there can be a problem with a shift linkage.
 SinsBird Member Submitted Tutorials & How To's 4 1,439 04-01-2023, 01:01 AM
    Thread: Is the 16v 1.6 hdi engine THAT bad?
Post: RE: Is the 16v 1.6 hdi engine THAT bad?
No. Just a regular engine, nothing special.
 SinsBird M59 Berlingo 8 2,821 28-12-2022, 07:15 PM
    Thread: Bearing Noise (road speed related)
Post: RE: Bearing Noise (road speed related)
Lower viscosity = less force required for gear to engage, higher = more.
 SinsBird M59 Berlingo 15 1,077 12-12-2022, 02:31 PM
    Thread: Bearing Noise (road speed related)
Post: RE: Bearing Noise (road speed related)
Check the gearbox oil level first. It might last a reasonable amount of time without repairing it but there would be less parts to replace if done soon.
 SinsBird M59 Berlingo 15 1,077 12-12-2022, 11:50 AM
    Thread: broken ignition lock
Post: RE: broken ignition lock
I'm not aware of any 'proper' chargers on the market that would set the required charging voltage based on the ambient temperature. I'm using a bench power supply for maximum properness. The sound met...
 SinsBird M59 Berlingo 21 1,152 12-12-2022, 11:34 AM
    Thread: broken ignition lock
Post: RE: broken ignition lock
Put your ear close to the charging battery, if it's making noise, it's full. A good fully charged battery after sitting for some time will have open circuit voltage above 12.6 V . While charging the v...
 SinsBird M59 Berlingo 21 1,152 12-12-2022, 09:14 AM
    Thread: broken ignition lock
Post: RE: broken ignition lock
I would try to spray WD into the barrel, then bang it a lot, try the key, repeat.
 SinsBird M59 Berlingo 21 1,152 10-12-2022, 04:22 PM
    Thread: broken ignition lock
Post: RE: broken ignition lock
Try harder to turn the key just don't break it off.
 SinsBird M59 Berlingo 21 1,152 10-12-2022, 03:37 PM
    Thread: Oil Pressure Light & Clattery Noises after flat battery.
Post: RE: Oil Pressure Light & Clattery Noises after fla...
I wouldn't ignore the light and wouldn't start the car without verifying that the oil pressure is sufficient. Might be the valve lifters clattering cause of no oil pressure.
 SinsBird M59 Berlingo 53 3,996 07-12-2022, 08:21 PM
    Thread: Wheel nut torque
Post: RE: Wheel nut torque
Same torque 90 Nm
 SinsBird K9 Third Generation 5 1,306 05-12-2022, 09:13 PM
    Thread: Do you think this sound is from bad rear axle bearing?
Post: RE: Do you think this sound is from bad rear axle ...
Rubbing rubber usually makes that sound.
 SinsBird M59 Berlingo 9 1,035 30-11-2022, 11:32 PM
    Thread: Potential purchase
Post: RE: Potential purchase
If oil and coolant are not mixing you could try a head gasket sealer. After repair be sure to take the car to LPG specialist to check if the air/fuel mix is correct.
 SinsBird M59 Berlingo 9 755 16-11-2022, 11:38 AM
    Thread: Battery
Post: RE: Battery
Don't look at CCA, it doesn't matter, you'll have a hard time finding a battery that's too weak to crank the engine. Manufacturers can use tricks to make CCA high, but the battery won't last.
 SinsBird B9 Second Generation 4 523 15-11-2022, 10:11 AM
    Thread: Two simple jobs done.. now WON'T START 2.0 hdi
Post: RE: Two simple jobs done.. now WON'T START 2.0 hdi
When fluid wasn't coming out but I could hear washer pump pressurising I blew air into the fluid line with a tyre pump until I heard bubbling in the fluid reservoir.
 SinsBird M49 Berlingo 15 1,469 12-11-2022, 09:44 AM
    Thread: Steering problem
Post: RE: Steering problem
Jack one side up, wiggle the wheel, do that with the other side, see if one side is significantly different.
 SinsBird M49 Berlingo 5 705 10-11-2022, 12:04 PM