Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Transmission] Berlingo drive shaft oil seal replacement advice please.
#1
Hi
Just wondering if anyone has a how to guide on replacing the oil seal in my gearbox where the drive shaft goes fits into.(passenger side) please. 2004 Berlingo 1.9d
I am assuming it is the oil seal.
I replaced the strut yesterday and while replacing it the hub pulled the drive shaft out a little bit and oil started to leak from the gearbox. i pushed the drive shaft back in which stopped the oil(or so i though) coming out quickly but when i got up this morning there is a drip coming from the gearbox where the shaft goes in.
Reply
#2
How much oil? It may only be residual oil dropping off.
Strawberry flavoured windows  Dodgy
Reply
#3
Thanks for the reply Ron.
I thought it was maybe residual oil but i cleaned the oil up from last night and there was a little pool this morning and its kept dripping throughout today. Sad
Reply
#4
The seal is easy to replace just be careful to drift it in square & feed the shaft in slow & level.While you're at it,changing the trans oil is always a good idea.Synthetic,of course. Wink Big Grin
Strawberry flavoured windows  Dodgy
[-] The following 1 user says Thank You to ron for this post:
  • tmm
Reply
#5
On the nearside the job is as it looks but when I did the seal on mine I found the CV joint was badly choroded where it meets the seal so I had to wire wool the face to a smooth clean finish. No problems since ( fingers crossed ) it has been approx 15k miles ... The Drivers side I haven't attempted yet..
Black Hyundai i30 1.6CRDI 2011
Silver 1.9D Mutispace desire 2004 DW8B non Turbo..
White 1.9D Van 2005 DW8B non turbo..
Silver MGF 1.8 16v 1999
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
ServiceBox
Last Post: nonce
Yesterday 03:28 PM
» Replies: 13
» Views: 3004
Limp mode, no other symptoms.
Last Post: smutts
Yesterday 11:37 AM
» Replies: 3
» Views: 176
Adding aircon oil after component replacement
Last Post: smutts
Yesterday 11:23 AM
» Replies: 6
» Views: 229
Centre Air Vent On Dash
Last Post: evdama
06-07-2025 10:50 AM
» Replies: 1
» Views: 54
1.5 Blue HDi info: oil and chain
Last Post: Opensauce
05-07-2025 11:41 AM
» Replies: 36
» Views: 58534
2.0 hdi clutch
Last Post: evdama
05-07-2025 06:20 AM
» Replies: 7
» Views: 499
Solenoide, Wastegate
Last Post: Multispacer
05-07-2025 02:27 AM
» Replies: 1
» Views: 87
All NS front head lamp bulbs blown?
Last Post: Multispacer
05-07-2025 02:15 AM
» Replies: 2
» Views: 116
Power steering Leak
Last Post: AugustinoHippo
01-07-2025 11:09 AM
» Replies: 5
» Views: 175
install other safetywall
Last Post: mikeh79
01-07-2025 09:48 AM
» Replies: 4
» Views: 153

[-]
Recent Visitors
Locations of visitors to this page

[-]
Hosting by

QuickHostUK