Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] Rev counter
#1
Quite a complex problem .. So here goes!
We changed an engine (1.9 ) on a Berlingo.Replaced the three wire pump solenoid with a single wire solenoid.
I now have no rev counter & a battery light on the dash.
The van will then go into Eco mode after 10mins ( lose dashboard, headlights etc) as I assume it thinks the engine isn't running.
The signal wire coming from the alternator has continuity up to the ecu.
Battery/ alternator is charging at 14.4 v -normal
I have changed the crank sensor
Does the Rev counter pick up from the crank sensor?
Anyone have any ideas to a very specific problem!
Possible ecu fault but it didn't have this problem before we changed the engine!
Reply
#2
(13-03-2016, 08:34 PM)Nik Buck Wrote:  Quite a complex problem .. So here goes!
We changed an engine (1.9 ) on a Berlingo.Replaced the three wire pump solenoid with a single wire solenoid.
I now have no rev counter & a battery light on the dash.
The van will then go into Eco mode after 10mins ( lose dashboard, headlights etc) as I assume it thinks the engine isn't running.
The signal wire coming from the alternator has continuity up to the ecu.
Battery/ alternator is charging at 14.4 v -normal
I have changed the crank sensor
Does the Rev counter pick up from the crank sensor?
Anyone have any ideas to a very specific problem!
Possible ecu fault but it didn't have this problem before we changed the engine!

It wold be best to connect the car to some diagnostic and see if diagnostic is showing revs.
That would exclude dash... 

Best regards,
brajomobil
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Grizz' Prozac for the Soul - Berlingo Multispace
Last Post: Grizz
Yesterday 10:13 PM
» Replies: 355
» Views: 45480
Clutch cable mounting plate?
Last Post: geoff
Yesterday 09:49 PM
» Replies: 4
» Views: 420
1.6 hdi lumpy cold start
Last Post: Zion
Yesterday 09:28 PM
» Replies: 52
» Views: 6687
Bypass heater matrix?
Last Post: Zion
Yesterday 09:11 PM
» Replies: 3
» Views: 592
Radio wiring.
Last Post: Zion
Yesterday 09:07 PM
» Replies: 11
» Views: 1519
newbie
Last Post: weldore
Yesterday 08:00 PM
» Replies: 2
» Views: 168
Peugeot partner 2.0 hdi 90, will a 406 2.0 hdi 1...
Last Post: Civvic
Yesterday 02:40 PM
» Replies: 1
» Views: 396
FOR SALE Amdro Bootjump £1100
Last Post: Elbie
Yesterday 01:11 PM
» Replies: 0
» Views: 158
Dingo - 05 - 2.0 HDI
Last Post: coakers
Yesterday 10:13 AM
» Replies: 80
» Views: 16889
Panoramic sunroof (+2008) model for weekend camp...
Last Post: Elbie
Yesterday 10:02 AM
» Replies: 5
» Views: 717

[-]
Recent Visitors
Locations of visitors to this page