Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Brakes] Front left brake binding on
#1
Been having a problem with front brake binding on,  this only happens when I am on a run and van is well warmed up. When binding on the pedal is very hard, a few pumps and everything goes back to normal.
I traveled about 15 miles up the motorway the other day and I could feel it slowing me down and when I pulled over I had smoke coming from the front left wheel.
Gave it a few pumps and all fine again.
So I had the wheel off and noticed the discs were not great so fitted new discs, pads and a new flexy hose as I was told these could be problem breaking down inside.
Everything has been fine this last week just using the van around town but took it on a run up the motorway again today and it started binding again, could smell burning brake pads and holding me back.

Would anyone know a simple fix for this please as fed up with spending money on the thing now.

Its a 2007 enterprise van.

Cheers
Reply
#2
I was going to say flexi hose but you've done that.


I'm guessing that as you have had it to bits to fit new discs etc., that the obvious was checked over, like...

Is the calliper moving nice and free on it's sliders?

Is the calliper piston nice & free?  pump it out and push it back a few times.

Are the brake pads free to move and not too tight on their mounts?


.
My vehicle .... 2006 (m59) Berlingo Multispace Desire - 1.6 HDI 92 
Reply
#3
(05-11-2016, 05:37 PM)jj9 Wrote:  I was going to say flexi hose but you've done that.


I'm guessing that as you have had it to bits to fit new discs etc., that the obvious was checked over, like...

Is the calliper moving nice and free on it's sliders?

Is the calliper piston nice & free?  pump it out and push it back a few times.

Are the brake pads free to move and not too tight on their mounts?


.

Yes all the above checked and in working order.
Reply
#4
1.6 HDI engine right ? ( gained from reading your earlier posts)

Have you had any brake related work done on the van prior to this fault...Master cylinder, servo etc?

Has it got ABS?

Did you clean the hub up prior to fitting the new disc? any rust on there where the new disc is sitting?

Wheel bearing, is the left side wheel bearing knackered?...
Rest fingers on the the suspension spring when rotating the wheel...compare to the right side...is the vibration the same?

Are you sure the calliper is ok?....have you actually checked it or are you assuming?

.
My vehicle .... 2006 (m59) Berlingo Multispace Desire - 1.6 HDI 92 
Reply
#5
(05-11-2016, 05:08 PM)Gazo Wrote:  Been having a problem with front brake binding on,  this only happens when I am on a run and van is well warmed up. When binding on the pedal is very hard, a few pumps and everything goes back to normal.
I traveled about 15 miles up the motorway the other day and I could feel it slowing me down and when I pulled over I had smoke coming from the front left wheel.
Gave it a few pumps and all fine again.
So I had the wheel off and noticed the discs were not great so fitted new discs, pads and a new flexy hose as I was told these could be problem breaking down inside.
Everything has been fine this last week just using the van around town but took it on a run up the motorway again today and it started binding again, could smell burning brake pads and holding me back.

Would anyone know a simple fix for this please as fed up with spending money on the thing now.

Its a 2007 enterprise van.

Cheers

Had the same problem:
http://www.berlingoforum.co.uk/thread-9935.html

Best regards,
brajomobil
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Welding sills
Last Post: Martinez
Today 01:41 PM
» Replies: 2
» Views: 236
Dispatch / Expert or B9?
Last Post: cancunia
Today 01:28 PM
» Replies: 0
» Views: 6
lower control arm replacement on 55 plate Berlin...
Last Post: cancunia
Today 01:14 PM
» Replies: 7
» Views: 300
Partner Camper Build
Last Post: Gravity
Yesterday 07:53 PM
» Replies: 6
» Views: 803
Another central locking problem
Last Post: ffrenchie
Yesterday 07:30 PM
» Replies: 6
» Views: 526
1.4L Petrol Won't Start: Spark and fuel ok, engi...
Last Post: polar
Yesterday 07:08 PM
» Replies: 3
» Views: 287
SMEG+ Firmware update
Last Post: Matt Haigh
Yesterday 06:47 PM
» Replies: 2
» Views: 1400
Airbag Warning Light
Last Post: killie77
Yesterday 05:44 PM
» Replies: 4
» Views: 283
Grizz' Prozac for the Soul - Berlingo Multispace
Last Post: Grizz
Yesterday 04:04 PM
» Replies: 740
» Views: 178945
OBD Scanner
Last Post: cancunia
Yesterday 01:15 PM
» Replies: 3
» Views: 291

[-]
Recent Visitors
Locations of visitors to this page