Thread Rating:
  • 1 Vote(s) - 5 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] No Fuel to Injectors
#31
(03-10-2018, 07:17 AM)cancunia Wrote:  9HT is a 75HP engine according to one of the threads I saw on this forum, but no ideas if it has a DPF:

https://www.berlingoforum.com/thread-101...ht=1.6+hdi

There are 2 ways to tell, with one being certain, that's to look at the exhaust in front of the engine to see if there are sensors before & after the big can, the other way being to look on catcar with your vin entered.

Hi cancunia,

I done some investigation work today and it most certainly doesn't have the DPF on my model.
Reply
#32
i think the 75hp model is an economy mapped 90hp, so praps it passed euro5 and does,nt need a dpf ?
https://www.berlingoforum.com/thread-10036-page-2.html
Reply
#33
(04-10-2018, 01:00 AM)Jmick Wrote:  I done some investigation work today and it most certainly doesn't have the DPF on my model.

Well, that's some good news! I think you need a code reader before going much further partly so you can see the OBD trouble (DTC) codes, but also take a look at the various live readings for boost & fuel pressure etc. They're cheap & the basic Torque app is free.
Reply
#34
(28-09-2018, 08:24 AM)Jmick Wrote:  
(27-09-2018, 04:42 PM)Lighty Wrote:  Ok, this is probably not air in the system . 
If the Ecu does not see enough fuel pressure at the rail sensor, it will not turn the injectors on !.
You may have inadvertently caused an issue by removing them all, it only takes one to loose pressure & it won’t start .
We have sometimes had to tow them to start when carrying out injector work, this is not entirely professional as you cannot listen to the engine properly or observe what’s happening on the end of a rope. 
You can sometimes get them to fire by using brake cleaner into the intake or easy start. This causes the engine to run without using the injectors, & the higher speed of the diesel pump I.e. 900rpm (engine running) is better tan 300rpm on the starter motor.
Usually once the engine has run for a few moments & cleared any air leaks/sticky injectors, it will start as normally .
Hope this helps .

Hi Lighty and thanks for the reply!

I've now managed to get it running but its now pinking which it didn't do before I replaced the injector seals Confused Its also still very black soot smokey and appears to be misfiring occasionally on pick up. I've had a few people say its an EGR problem and it was previously showing anti pollution fault on the display which has now vanished Huh  I've had it looked at by my local garage and he has said its the DPF that needs replaced.

How did you get it running in the end? I'm having the same problem. New injector seals and fuel filter and now it's just turning and turning
Reply
#35
Jmick hasn't been on the forum for 5 years mate, and sadly Lighty passed away a couple of years ago now.

I think the answer is getting any air out of an injector if you disturbed them. Only one needs to have air in it to cause a no-start. Don't try and crack one open to bleed it, as the pressure from the pump is dangerous even at idle.
______________________
Current:
Not a Citroen!
______________________
Previous:
2017 B9 1.6 BlueHDi Van
2012 B9 1.6 HDi Van
2008 M59 1.6 HDi Van
2003 M59 1.9D Van
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Service interval notice
Last Post: jocas74
Today 02:23 AM
» Replies: 7
» Views: 358
Winter Tyres
Last Post: geoff
Today 12:19 AM
» Replies: 0
» Views: 16
23 plate Citreon Berlingo classed as a van
Last Post: W Petsa
Yesterday 10:39 PM
» Replies: 2
» Views: 34
The creation of my personal solo-travellor.
Last Post: EM58
Yesterday 06:17 PM
» Replies: 12
» Views: 740
M59 Throttle pedal
Last Post: evdama
Yesterday 01:10 PM
» Replies: 5
» Views: 178
Berlingo 2007 1.6 hdi - intermittent sticky acce...
Last Post: Romahomepete
Yesterday 01:05 PM
» Replies: 7
» Views: 328
roof rack with slats
Last Post: BigVtwin996
Yesterday 11:53 AM
» Replies: 4
» Views: 192
Battery upgrade
Last Post: evdama
27-03-2024 03:58 PM
» Replies: 0
» Views: 99
Wanted: 2003 M59 steering rack
Last Post: evdama
27-03-2024 12:45 PM
» Replies: 1
» Views: 57
Airbag Fault Code
Last Post: Cumbrian
26-03-2024 03:06 PM
» Replies: 1
» Views: 214

[-]
Recent Visitors
Locations of visitors to this page

[-]
Hosting by

QuickHostUK