Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Brakes] Clutch fluid......
#1
Hi everyone my first post iv go a 08 multispace 1.6? Which has turned out to be the best car ever...to the point im keeping it over wants of jags and mercs!! Anyway it just hit 50k and ive had to change the front pads not bad for 10 years!! But noticed fluid over the front running gear...but checked the res and its full no visibke leaks in the engine bay area the brakes are solid but clutch has lot of travel so were would this be leaking from?i can see fluid tracking down the 2 pipes that run under the floor.....
Reply
#2
Hi wellmound and welcome to the forum.

When you replaced your pads you pushed the pistons on the callipers back in to fit the new thicker pads. I suspect the brake fluid is coming out of the breather hole in the brake fluid reservoir - as you push the pistons in the fluid displaced must go somewhere. You could have caused damage to the master cylinder seals (flip them due to pressure) This could be the problem with the clutch as it uses the same reservoir, to may have damaged the clutch slave cylinder seals also.

I suggest you bleed the front brakes and the clutch to remove the excess fluid and make sure you have not damaged the seals.
Reply
#3
Thanks the break pedals quite hard no spongyness so hopefuly its just over flow thanks
Reply
#4
(10-10-2018, 07:09 PM)Wellmound Wrote:  Thanks the break pedals quite hard no spongyness so hopefuly its just over flow thanks

Same happened to me when I replaced my pads last year.
Best practice (as I discovered after) is to bleed the excess fluid out of the calipers by opening the bleed screw before pushing the pistons back in.
I've done plenty of pads before but the Blingo is the first I had this problem with.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Engine noise
Last Post: polar
Yesterday 10:23 PM
» Replies: 18
» Views: 3295
tensioner pulley
Last Post: RJBingham
17-02-2019 07:18 PM
» Replies: 19
» Views: 3613
Eberspacher or similar
Last Post: David Edwards
15-02-2019 01:10 PM
» Replies: 13
» Views: 3543
Overheat and antipollution?
Last Post: mikeB
15-02-2019 11:39 AM
» Replies: 26
» Views: 6743
Grizz' Prozac for the Soul - Berlingo Multispace
Last Post: Grizz
14-02-2019 10:04 PM
» Replies: 651
» Views: 136138
clutch pedal
Last Post: gissa
14-02-2019 12:43 PM
» Replies: 8
» Views: 1918
Valves DW8
Last Post: Arbe
13-02-2019 11:11 AM
» Replies: 51
» Views: 10820
throttle cable - where to get a good one.
Last Post: Arbe
12-02-2019 05:35 PM
» Replies: 9
» Views: 2717
2003 2.0 HDI Poor fuel consumption
Last Post: ffrenchie
12-02-2019 04:23 PM
» Replies: 31
» Views: 8055
New Berlingo Anyone????
Last Post: Tree
11-02-2019 11:13 AM
» Replies: 13
» Views: 4503

[-]
Recent Visitors
Locations of visitors to this page