Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] Ticking /Chuffing from Top of Engine 1.6 HDI
#1
Hi all,

Opinions on below please?

Ticking  / Chuffing noise from the top of the engine. Increases / decreases with revs, appears to be from top right when I remove the plastic cover - Doesn't APPEAR to be the injectors although they were loose and I've tightened them. Noise appears to be further back on top.

You Tube link:
YouTube Cuffing / Ticking noise from Engine
Reply
#2
Cant really tell mate - if its not coming from the injectors i wouldn't worry too much.
[-] The following 1 user says Thank You to polar for this post:
  • Requiem
Reply
#3
It sounds very much like blow by past the injector to me.


.
My vehicle .... 2006 (m59) Berlingo Multispace Desire - 1.6 HDI 92 
[-] The following 1 user says Thank You to jj9 for this post:
  • Requiem
Reply
#4
(13-10-2018, 04:02 PM)jj9 Wrote:  It sounds very much like blow by past the injector to me.


.

I agree, but it doesn't see to be around there - I think I'll leave it on the drive until Monday and get the local guys to have a look at it - thanks
Reply
#5
You should be able to see if you look closely at the base of the injectors, use a torch and get your head in there, if you can't see it maybe you can feel it.

.
My vehicle .... 2006 (m59) Berlingo Multispace Desire - 1.6 HDI 92 
[-] The following 1 user says Thank You to jj9 for this post:
  • Requiem
Reply
#6
We quite often get the egr valves blowing, usually because they are loose.
Not difficult to tighten up on the Berlingo, just requires removing the air box.
A good way to check the injectors is to get a piece of tube & hold it next to your ear.
Then just hover it around the engine next to,the noise, it works like a stethoscope & makes it very easy to pinpoint the source of the noise or blow.
[-] The following 3 users say Thank You to Lighty for this post:
  • jj9, Requiem, ron
Reply
#7
Well there you go all possibility covered, check the EGR valve isn't loose....

Hope you're lucky and it is loose, as that's easier to fix than an injector.


.
My vehicle .... 2006 (m59) Berlingo Multispace Desire - 1.6 HDI 92 
[-] The following 1 user says Thank You to jj9 for this post:
  • Requiem
Reply
#8
(13-10-2018, 05:27 PM)Lighty Wrote:  We quite often get the egr valves blowing, usually because they are loose.
Not difficult to tighten up on the Berlingo, just requires removing the air box.
A good way to check the injectors is to get a piece of tube & hold it next to your ear.
Then just hover it around the engine next to,the noise, it works like a stethoscope & makes it very easy to pinpoint the source of the noise or blow.

I guess a loose EGR valve will also cause a smell of exhaust gas from that area as well?
Reply
#9
The EGR sits right under the airbox and if the airbox works loose it will rub on top of the EGR sometimes causing damage. As Lighty says, it's easy enough to check, the EGR is held on by 2 8mm head bolts.
[-] The following 1 user says Thank You to cancunia for this post:
  • Requiem
Reply
#10
Quick update on this - I've taken this to a Garage who have advised that the 3 of the injectors are leaking, with carbon deposits and oil on the top of the engine underneath the cover.
Because I've only had the car for just over a month, and because it appears this fault existed at the time of purchase I'm going to contact the original company that sold the vehicle and invoke the Consumer Rights Act to get it repaired free of charge.

By the way, thanks to all for the advice - It really has been appreciated

Roy
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Service interval notice
Last Post: jocas74
Today 02:23 AM
» Replies: 7
» Views: 369
Winter Tyres
Last Post: geoff
Today 12:19 AM
» Replies: 0
» Views: 35
23 plate Citreon Berlingo classed as a van
Last Post: W Petsa
Yesterday 10:39 PM
» Replies: 2
» Views: 41
The creation of my personal solo-travellor.
Last Post: EM58
Yesterday 06:17 PM
» Replies: 12
» Views: 745
M59 Throttle pedal
Last Post: evdama
Yesterday 01:10 PM
» Replies: 5
» Views: 186
Berlingo 2007 1.6 hdi - intermittent sticky acce...
Last Post: Romahomepete
Yesterday 01:05 PM
» Replies: 7
» Views: 333
roof rack with slats
Last Post: BigVtwin996
Yesterday 11:53 AM
» Replies: 4
» Views: 196
Battery upgrade
Last Post: evdama
27-03-2024 03:58 PM
» Replies: 0
» Views: 103
Wanted: 2003 M59 steering rack
Last Post: evdama
27-03-2024 12:45 PM
» Replies: 1
» Views: 60
Airbag Fault Code
Last Post: Cumbrian
26-03-2024 03:06 PM
» Replies: 1
» Views: 219

[-]
Recent Visitors
Locations of visitors to this page

[-]
Hosting by

QuickHostUK