Posts: 140
Threads: 20
Thanks Received: 7 in 7 posts
Thanks Given: 0
Joined: Sep 2013
Location: England
Reputation:
0
A very quiet whistling wind sound.
Noticed this recently, seems to be coming from the front end and checked to make sure all doors etc are firmly closed.
Starts to be noticeable at about 45mph, dropped a gear to see if engine related as I was worried it might be turbo related. but still only at 45mph so not revs/engine related (or is my logic incorrect).
I have a feeling it started after I had the front and back tyres reversed, all in very good condition. Plus balancing.
Any ideas please.
Multispace B9 2009 1.6HDi
•
Posts: 559
Threads: 28
Thanks Received: 84 in 64 posts
Thanks Given: 78
Joined: Feb 2016
Location: Uk
Reputation:
3
Is it possible that wind is getting past the bonded wind screen ?
I've had that happen in my vivaro.
Mark
Sent from my VFD 710 using Tapatalk
•
Posts: 140
Threads: 20
Thanks Received: 7 in 7 posts
Thanks Given: 0
Joined: Sep 2013
Location: England
Reputation:
0
Thanks..
I'll have to wait until I have a passenger as it seems to be from the front left. I don't think it's the windscreen but will check
I don't think it gets louder as speed increases, going to check tonight, going on a motorway that hasn't got any roadworks
Multispace B9 2009 1.6HDi
•
Posts: 175
Threads: 7
Thanks Received: 42 in 35 posts
Thanks Given: 0
Joined: Oct 2018
Location: Kent
Reputation:
0
I would hazard a guess that the noise that sounds like a slight wind/draught is in fact a slight wind/draught...
No seriously start looking for rubber bungs missing in the bulk head. The foam bits on either side of the scuttle panel also degrade, I've had it on other models of car where once this bit of foam is missing you get wind noise.
•
Posts: 140
Threads: 20
Thanks Received: 7 in 7 posts
Thanks Given: 0
Joined: Sep 2013
Location: England
Reputation:
0
Thanks for all the ideas. Volume doesn't increase with speed although road noise might disguise it.
I'm hoping I've found the problem but how to cure it? I have no idea yet so any ideas offered are welcome.
Looking at the picture (not my Berlingo) the plastic moulding running from left to right at the base of the windscreen with the plastic mesh in the middle seems to be fixed against the screen?
On the passenger side from in the corner where the plastic mould starts then towards the centre for approx 12 inches the mould has lifted, so much so that those helicopter tree seeds can slide down inside so who knows where they are ending up, another question but that ones for later
I'm thinking this is the cause of the wind noise problem as that is about the right area.
https://www.locator.co.uk/images/content...24x704.jpg
Multispace B9 2009 1.6HDi
•
Posts: 175
Threads: 7
Thanks Received: 42 in 35 posts
Thanks Given: 0
Joined: Oct 2018
Location: Kent
Reputation:
0
The plastic shuttle cover should slide under the bottom of the screen I think. It's probably been off to access an EGR valve or something in the past and hasn't been put back properly
•
Posts: 140
Threads: 20
Thanks Received: 7 in 7 posts
Thanks Given: 0
Joined: Sep 2013
Location: England
Reputation:
0
Ta. so it's called a shuttle cover, handy to know if I ring Citroen.
Just had a quick look under torchlight so will check again tomorrow.
All along the cover it is flush on the screen not under it.
Multispace B9 2009 1.6HDi
•
Posts: 559
Threads: 28
Thanks Received: 84 in 64 posts
Thanks Given: 78
Joined: Feb 2016
Location: Uk
Reputation:
3
I thought it was called a scuttle, You live and learn !
Mark
Sent from my VFD 710 using Tapatalk
•
Posts: 140
Threads: 20
Thanks Received: 7 in 7 posts
Thanks Given: 0
Joined: Sep 2013
Location: England
Reputation:
0
Looks like scuttle is correct as I get search hits with it.
It seems there are clips but not found anything definitive.
Top edge of scuttle definitely sits on top of the windscreen along the whole width.
Multispace B9 2009 1.6HDi
The following 1 user says Thank You to magoo for this post:1 user says Thank You to magoo for this post
• Satellitemark
Posts: 175
Threads: 7
Thanks Received: 42 in 35 posts
Thanks Given: 0
Joined: Oct 2018
Location: Kent
Reputation:
0
yep scuttle, it got auto corrected.
•