Thread Rating:
  • 4 Vote(s) - 2.25 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Airbag MOT Fail
#1
The light has been on dash for 4 years but laws have now changed so ta-dah here we are FAILED
Unit next to MOT station read fault on a bosch not Lexia , the results being
801 Ignition circuit,driver-side
airbag, stage 1
Open circuit .
MOT guy reckons this could mean one of three problems;
the bag itself
the wiring
the igniter
can anyone give the guy anything else to work from ?

Also , would a lexia plug-in guarantee a more precise diagnostic ? I stress guarantee as the Citroen dealership has been swallowed up by KIA so goodness knows where I will find Lexia near me :eek:
Fingers crossed , cheers in advance n b m.
Reply
#2
Citroen Dealership in Lichfield Street, Stafford.... don't know how good they are ???? Good indy repairer here in North Staffs if you want to venture further afield http://www.richard-dalton.com/classic_citroen.html
Berlingo Multispace 2.0HDI '54 reg Mediterranean Blue
Reply
#3
Blimey that was a quick reply A.W. his number is at bottom of link so cheers for another option :thumbsup: will give him a tinkle tomorrow .
[-] The following 1 user says Thank You to nil by mouth for this post:
  • andy-womble
Reply
#4
(06-10-2013, 09:26 PM)nil by mouth Wrote:  The light has been on dash for 4 years but laws have now changed so ta-dah here we are FAILED
Unit next to MOT station read fault on a bosch not Lexia , the results being
801 Ignition circuit,driver-side
airbag, stage 1
Open circuit .
MOT guy reckons this could mean one of three problems;
the bag itself
the wiring
the igniter
can anyone give the guy anything else to work from ?

Also , would a lexia plug-in guarantee a more precise diagnostic ? I stress guarantee as the Citroen dealership has been swallowed up by KIA so goodness knows where I will find Lexia near me :eek:
Fingers crossed , cheers in advance n b m.

Yes, Lexia will tell you exactly what the problem is.

I have the same problem on mine. "remote Airbag igniter short to earth" is what Lexia says.

Haven't fixed it yet mind you..
Reply
#5
Almost certainly the clock spring. It's easily damaged and can be mis-installed.
Reply
#6
(06-10-2013, 09:39 PM)nil by mouth Wrote:  Blimey that was a quick reply A.W. his number is at bottom of link so cheers for another option :thumbsup: will give him a tinkle tomorrow .

Just wonder how you went on at Richard Dalton's ???

My visit was due to loose steering wheel, didn't want the hassle of removing airbag and risking FUBAR of something expensive..... In less than the time it would have taken me to find my tools and get started it was in, out and done and dusted.... Cost me £25.00 which I thought was money well spent and I will be going back there.
Berlingo Multispace 2.0HDI '54 reg Mediterranean Blue
Reply
#7
(07-10-2013, 01:58 PM)andy-womble Wrote:  
(06-10-2013, 09:39 PM)nil by mouth Wrote:  Blimey that was a quick reply A.W. his number is at bottom of link so cheers for another option :thumbsup: will give him a tinkle tomorrow .

Just wonder how you went on at Richard Dalton's ???

My visit was due to loose steering wheel, didn't want the hassle of removing airbag and risking FUBAR of something expensive..... In less than the time it would have taken me to find my tools and get started it was in, out and done and dusted.... Cost me £25.00 which I thought was money well spent and I will be going back there.

Spoke with Mark who answered phone , really friendly , knowledgeable and helpful , his response clarified one point ; Lexia would pin-point exact problem .
He suggested I pop in but when I said I was 50 miles away he mentioned a Stafford dealership closer to me , what a bloke !
Told Mark I would sooner travel to a womble endorsed garage than main dealer Big Grin

He advised firstly to check connections under seats
then connection behind steering wheel ( clock spring , as ADDO Confusedalut: suggested ) , possible £££££ if coms unit is problem :eek:.
I've seen coms unit posts but not read any 'cos I've never heard of it .....Confusedtudy:
If only your man was round the corner I'd be lining his pockets on a regular basis .

Anyhooo , van goes in tues night for a couple of ball joints to me local MOT guy and hes gonna have a look see , armed with this info , with a bit of luck ............
[-] The following 1 user says Thank You to nil by mouth for this post:
  • andy-womble
Reply
#8
Good luck.:thumbsup:Confusedalut:
Strawberry flavoured windows  Dodgy
Reply
#9
Well , I'm over the moon as all lights now behave themselves on dash but me paperwork read " repairs to fail " so I can't be forum friendly Confusedillyme:
Only receptionist in when I picked up the sportscar so no-one to grill !
Off I drove into the sunset listening to the familiar twangs and bongs from front n rear :lol: She's back :thumbsup:
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
New Berlingo Anyone????
Last Post: msw109
Today 08:25 PM
» Replies: 0
» Views: 21
FK Lowering kit actual drop
Last Post: Matt Haigh
Today 05:05 PM
» Replies: 6
» Views: 621
My new partner (well it’s the same van!)
Last Post: dumdum
Today 04:05 PM
» Replies: 4
» Views: 436
Lowering fun
Last Post: northroadycles
Today 11:12 AM
» Replies: 11
» Views: 1570
Plug phone into stereo?
Last Post: LukeLog
Today 10:27 AM
» Replies: 6
» Views: 839
Modutop Door Hinges - Cable tie repair
Last Post: ghost123uk
Today 09:14 AM
» Replies: 12
» Views: 7800
Grizz' Prozac for the Soul - Berlingo Multispace
Last Post: ffrenchie
Today 09:00 AM
» Replies: 627
» Views: 123292
How Often Does AC Need Re-Gassing?
Last Post: cancunia
Today 08:51 AM
» Replies: 18
» Views: 2030
Loose connectors under dash
Last Post: brodfather11
Today 07:18 AM
» Replies: 1
» Views: 339
How did the Berlingo get it's name ?
Last Post: hawaiianblue
Yesterday 05:30 PM
» Replies: 14
» Views: 2742

[-]
Recent Visitors
Locations of visitors to this page